logo
* 搜尋
* 核能資訊中心
* 中心簡介
* 相關資訊
* 瀏覽人數
今天: 109
昨天: 272
本月: 3471
總計: 557324
國際核能現況 : Rosatom launches annealing technology for VVER-1000 units
發表人 nicenter 於 2018/11/28 9:51:44 (23 人讀取)

Rosatom launches annealing technology for VVER-1000 units


Rosatom announced yesterday it has extended the service life of unit 1 of its Balakovo nuclear power plant in the Saratov region of Russia by using thermal annealing on the VVER-1000's reactor pressure vessel. The Russian state nuclear corporation said it was a global first for the industry to anneal a large-capacity RPV and that the technology could extend the service lives of VVER-1000 units around the world by up to 30 years.




Annealing of the RPV of Balakovo unit 1 (Image: Rosatom)

The technology used for the procedure, which was designed by scientists from the Kurchatov Institute, uses heat treatment to restore the original physical properties of the metal in an RPV.


"Today, there are about 37 VVER-1000 around the world. Annealing [of a reactor vessel] is a new and, currently, only technology in the world that enables the extension of the service life of a reactor. This technology will be available for export," Rosatom Director General Alexey Likhachov said.


Annealing could extend the service life of VVER-1000s by between 15 and 30 years, thus helping to avoid global emissions of up to 7.8 billion tonnes of CO2, as well as boost the safety and economic performance of nuclear power plants, Rosatom said. For the extended operational service period, the levelised cost of energy could decrease to as little as USD29 per MWt-hour, which is less than the marginal cost of coal-fired power generation, it added.


Mikhail Kovalchuk, president of the Kurchatov Institute, noted that the long-term operation of VVER-type reactors under neutron irradiation leads to the degradation of the metal properties in RPVs, which limits the service life of the given nuclear power plant. The patented VVER-1000 RPV recovery annealing technology can be adapted for water-moderated nuclear power units of any design and capacity, he said.


The pilot recovery annealing of the RPV of unit 1 of the Balakovo plant was carried out this month and led to the recovery of the structure and mechanical properties of the RPV’s metal to its original state, he said, adding that the procedure had extended the unit's service life by 15 years.


Previously, similar technology was tried and tested at smaller reactors of medium capacity - VVER-440s - at the following nuclear power plants: Novovoronezh and Kola in Russia, Rovno in Ukraine, Metsamor in Armenia, Greifswald in Germany and Kozloduy in Bulgaria. Annealing enabled an extension to the service lives of these of between 45 and 60 years, Rosatom said.


The VVER-1000 RPV is larger in diameter and has thicker steel structures than the VVER-440 RPV, thus requiring development of a new technology for the annealing of large-capacity RPVs, it said. The metal in the RPV was slowly heated to a temperature of +565 degrees Celsius, after which began the “stationary annealing” process, which lasted 100 hours. The metal was then slowly cooled.


All the technical data gathered during the procedure will be compiled into a report that will be submitted to the national regulator, Rostekhnadzor, "for approval to conduct further reactor operations", it added.


Researched and written by World Nuclear News



source: http://www.world-nuclear-news.org/Articles/Rosatom-launches-annealing-technology-for-VVER-100



其他新聞
2018/12/12 9:32:00 - Work starts on Kursk II-2 foundation plate
2018/12/12 9:29:31 - Optimisation studies begin at Namibian uranium mine
2018/12/12 9:26:06 - South African government replaces Necsa board
2018/12/12 9:24:27 - Nigeria becomes HEU free
2018/12/12 9:21:47 - Fuqing 6 reactor pressure vessel in place
2018/12/10 9:24:45 - Fusion reactions project attracts UK funding
2018/12/10 9:22:58 - China General Nuclear ready to ramp up UK ambitions
2018/12/10 9:21:22 - Diversity key for UK nuclear workforce strategy
2018/12/10 9:19:35 - Optimisation studies begin at Namibian uranium mine
2018/12/7 10:41:45 - Nuclear important to sustainable energy mix, says UNECE report
2018/12/7 10:40:07 - First Taiwanese reactor to enter decommissioning
2018/12/7 10:31:03 - Russia completes testing of modified VVER-440 fuel
2018/12/7 10:30:00 - 核一廠1號機於107年12月6日進入除役期間,原能會將嚴格監督台電公司落實除役計畫及安全要求
2018/12/7 10:29:55 - Russia and Rwanda to cooperate in nuclear power
2018/12/7 10:20:00 - 核一廠1號機執照屆滿依法停機 待取得除役許可正式啟動除役
2018/12/7 10:19:17 - 回應新北市府指核一乾貯未按圖施工 台電:配合地形調整減少開挖 盼與市府再溝通
2018/12/5 9:56:19 - Argentina, Russia expand nuclear energy cooperation
2018/12/5 9:53:07 - Lawsuit launched as Bellefonte sale falters
2018/12/5 9:51:20 - CNNC launches R&D centre for fuels and materials
2018/12/5 9:48:24 - Nuclear must remain in South African mix, committee finds

 線上期刊目錄

 友善連結

單位類

行政院原子能委員會
放射性物料管理局
核能研究所
國立清華大學工程與系統科學系
國立清華大學生醫工程與環境科學系
中華民國核能學會
財團法人核能科技協進會

新聞類


30013 新竹市光復路二段101號 創新育成中心三樓309室 電話:(03)571-1808 傳真:(03)572-5461 Email: nicenter@nicenter.org.tw